鋼邊止水帶(也稱：鋼邊橡膠止水帶)就是是橡膠止水帶斷面采用非等厚結構，分強力區和防水區，使各部分受力均勻，合理。在止水帶的鋼板上增設安裝孔與鋼筋相連接，固定牢靠不易位移，使各部分受力均勻，合理。
Steel edge stop water (also called steel edge rubber water stop belt) is the rubber sealing strip section adopts non equal thickness structure, divided into strong zone and waterproof zone, so that each part of the force is uniform, reasonable. An additional installation hole is installed on the steel plate of the water stopping strip to connect with the steel bar. The fixing is firm and the displacement is not easy, so that the force of each part is uniform and reasonable.
鋼邊止水帶的伸縮孔久壁為平面，止水帶施工時板模夾制接觸面大，不易脫位；鋼板增設安裝孔與鋼筋相連接，固定牢靠不易位移。
The expansion hole of the steel edge water stop belt is plane, and the clamping surface is large and difficult to be dislocated during the construction of the water stopping belt; the steel plate is additionally provided with an installation hole and is connected with the steel bar, and the fixing is firm and the displacement is not easy.
鋼邊橡膠止水帶的優勢
Advantages of steel edge rubber water stop
一般來說，混凝土和橡膠的粘附力較差，在常規施工中，又因橡膠是柔軟彈性體，使混凝土在澆筑時不易被搗實，故在混凝土接縫膨脹，扯離、扭轉時會經常出現橡膠止水帶松動和脫落，以致在水頭壓力較高情況下會產生滲漏現象。對于變形縫大的接縫來說，問題就更為。
In general, concrete and rubber adhesion is poor, in the conventional construction, because the rubber is soft and elastic body, which is not easy to be compacted in concrete pouring, the concrete expansion joints, tear and torsion will often appear rubber zhishuidai loose and fall off, that will produce leakage in the hydraulic pressure under the condition of higher. For the seams with large deformation joints, the problem is more prominent.
采用鍍鋅鋼邊橡膠復合式止水帶，基本上可以克服純橡膠橋式止水帶的這些不足。而且這種復合式止水帶還具有雙重功能，即一方面可以延長途徑，延緩滲水速度，另一方面鍍鋅鋼邊和混凝土有著良好的粘附性，使止水帶能承受較大的拉力和扭力，從而橡膠止水帶的混凝土中的有效變形范圍內不會產生松動和脫落現象，提高止水效果。
Galvanized steel edge rubber composite water stop belt can basically overcome the shortcomings of pure rubber bridge water stop belt. And this kind of composite type waterstop also has a dual function, on the one hand can extend the way, slow water penetration rate on the other hand, galvanized steel and concrete edge has good adhesion, the waterstop can withstand greater torque and tension, so as to ensure that the rubber seal is not valid in the range of deformation of concrete mixed with the the loosening and shedding phenomenon, improve the sealing effect.
鋼邊橡膠止水帶選用鍍鋅鋼邊；橡膠：通常選用天然橡膠、氯丁橡膠、三元乙丙橡膠等。要求橡膠和鋼邊能有效地粘結，它們之間的粘結強度（剝離強度）應達8~10N/2.5mm，以使它們在外界條件變化情況下不被拉脫。
The steel edge rubber waterproof belt selects galvanized steel edge; rubber: usually choose natural rubber, chloroprene rubber, three yuan ethylene propylene rubber and so on. Requirements of rubber and steel side can effectively bond, the bond strength between them (peel strength) should be 8~10N/2.5mm, to make them in the external condition changes are not.
通常鋼邊邊緣沒有工藝孔，安裝澆筑混凝土?xí)r，利用工藝將止水帶和鋼邊用細鐵絲纏繞固定，以澆搗密實，使鍍鋅鋼片和混凝土有效地牢固粘附。
Usually, there is no technological hole on the edge of the steel. When the concrete is installed, the water stop strip and the steel edge are fixed with fine iron wire to ensure the compactness of the pouring and tamping so as to make the galvanized steel sheet and the concrete effectively adhere to the dungeon.
本產品主要用于混凝土現澆時設在施工縫及變形縫內與混凝土結構成為一體的基礎工程，如地下設施、隧道涵洞、輸水渡槽、攔水壩、貯液構筑物等。
This product is mainly used in concrete cast-in-place construction joints and deformation joints and concrete structure has become one of the basic engineering facilities, such as underground tunnels, culverts, dams, aqueducts, liquid storage structures etc..
鋼邊橡膠止水帶使用安裝方法：鋼邊橡膠止水帶采用斷面采用非等厚結構，分強力區和防水區的一種橡膠止水帶產品，它使各部分受力均勻，合理。
Steel edge rubber waterproof belt use and installation method: steel edge rubber waterproof belt adopts cross section with non equal thickness structure, divided into strong zone and waterproof zone of rubber water stop belt product, it makes each part of the force evenly, reasonable.
鋼邊橡膠止水帶,鋼板增設安裝孔與鋼筋相連接，固定牢靠不易位移,使各部分受力均勻，合理。伸縮孔壁為平面，止水帶在施工時模板夾制接觸面大，不易脫位;鋼板增設安裝孔與鋼筋相連接，固定牢靠不易位移。
The steel edge rubber water stop belt is provided with an additional installation hole and a steel bar connected with the steel plate. The steel plate is firmly fixed and is not easy to shift, so that the force of each part is uniform and reasonable. The wall of the telescopic hole is plane, and the sealing surface of the water blocking belt is large and difficult to be dislocated during the construction; the steel plate is additionally provided with an installation hole and is connected with the steel bar, and the fixing is firm and the displacement is not easy.
鍍鋅鋼板與混凝土的良好粘接，鋼邊橡膠止水帶使防水性能更佳。本產品采用鍍鋅為原料，生產的鋼邊橡膠復合式止水帶，基本上可以克服純橡膠橋式止水帶的這些不足。
Good adhesion between galvanized steel sheet and concrete, and steel edge rubber water stop makes waterproof performance better. This product uses galvanized steel as raw material to produce steel edge rubber composite water stop belt, which can basically overcome the shortcomings of pure rubber bridge water stop belt.
而且這種復合式止水帶還具有雙重功能，即一方面可以延長途徑，延緩滲水速度，另一方面鍍鋅鋼邊和混凝土有著良好的粘附性，使止水帶能承受較大的拉力和扭力，從而橡膠止水帶的混凝土中的有效變形范圍內不會產生松動和脫落現象，提高止水效果。
And this kind of composite type waterstop also has a dual function, on the one hand can extend the way, slow water penetration rate on the other hand, galvanized steel and concrete edge has good adhesion, the waterstop can withstand greater torque and tension, so as to ensure that the rubber seal is not valid in the range of deformation of concrete mixed with the the loosening and shedding phenomenon, improve the sealing effect.
用途
purpose
主要用于基建工程、地下設施、隧道、污水處理廠、水利、地鐵等工程。為
It is mainly used in infrastructure projects, underground facilities, tunnels, sewage treatment plants, water conservancy, subway and other projects. by

查看全部介紹